Green Car Congress

JUNE 3, 2022

a Sumitomo Corporation Group company, jointly demonstrated a new waste heat recovery system based on a thermoelectric generator (TEG), which generates electrical power via exhaust gas heat. The TEG unit was installed in the exhaust pipe at the downstream of the catalyst. With the TEG, 1.9% of CO 2 emissions (i.e.

CO2 329

CO2 Exhaust Waste Gas-Electric 329

Green Car Congress

JUNE 8, 2023

The levels of these non-fuel-derived gases will likely remain unchanged, even as more drivers transition from gas-powered to electric vehicles. These emissions are independent of the vehicle energy/propulsion system and therefore applicable to all road vehicle types including those with battery-electric powertrains. Cliff et al.

Emissions 397

Emissions Exhaust Cars Ozone 397

Green Car Congress

MAY 7, 2021

is adding 53 all-electric transport refrigerated trailer units (TRUs) to its fleet located at the company’s Riverside, Calif. By operating the all-electric TRUs, UNFI anticipates it will save approximately 135,000 gallons of diesel fuel per year while reducing particulate matter pollutant emissions and greenhouse gas emissions.

All-Electric 435

All-Electric Fleet California Lithium Ion 435

Green Car Congress

MAY 8, 2017

IAV has developed a particularly closed-coupled diesel exhaust gas aftertreatment (EAT) system. A key contribution to this performance must come from the exhaust gas aftertreatment system—across the entire speed and load range. This way, exhaust gas flows through DOC and SCRF before it enters the turbine.

Exhaust 210

Exhaust Diesel Gas Emissions 210

Green Car Congress

AUGUST 14, 2023

The engine was also equipped with an electrically driven volumetric pump in the exhaust gas recirculation (EGR) path which gives the freedom to set any desired EGR rate, independently from the pressure ratios across the turbocharger. EGR system consisting of an EGR cooler, an electrically driven EGR pump and respective piping.

Engine 368

Engine Emissions Diesel Fuel 368

Baua Electric

MAY 1, 2024

For gas motorcycle riders, a scorching hot planet isn’t the only immediate source of discomfort outside. The benefit of riding electric is two-fold… The cold hard truth: electric motorbikes are the future First, and I know I’m preaching to the choir here, but electric motorcycles are clearly the future.

Electric Motorcycles 52

Electric Motorcycles Motorcycles Gas-Electric Gas 52

Green Car Congress

AUGUST 26, 2010

(MHI) has developed a generator-integrated hybrid turbocharger for marine propulsion diesel engines which utilizes engine exhaust gas not only to drive the turbocharger but also to generate electricity. The MET83MAG is capable of supplying all electric power necessary during normal sea going. Click to enlarge.

Exhaust 199

Exhaust Mariner Gas-Electric Gas 199

Green Car Congress

NOVEMBER 6, 2017

Stena Line is seeking novel, cost-effective approaches to recover energy from exhaust gases from ship engines and to transform it into a more useful energy form (e.g., electricity to supply hotel loads on board the ship). These energy losses are primarily radiant heat loss and the sensible heat of exhaust gases.

Exhaust 150

Exhaust Engine Energy Mariner 150

Green Car Congress

MARCH 31, 2021

Battery-electric AMG derivatives based on the new Mercedes Electric Vehicle Architecture (EVA) for luxury and premium-class vehicles. Extensive modifications to the drive, chassis, design and equipment will provide the hallmark AMG driving experience with all-electric drive. This is a P3 hybrid configuration.).

Mercedes 448

Mercedes Hybrid Battery Batteries 448

Green Car Congress

DECEMBER 6, 2021

To date, the technology has been evaluated with a close-coupled selective catalytic reduction (SCR) aftertreatment system with and without a 48-volt electric heater. Notably, using the same aftertreatment system with the addition of a 48-volt electric heater located upstream of the SCR further achieved a reduction in CO 2.

Eaton 221

Eaton Emissions Exhaust Commercial 221

Green Car Congress

OCTOBER 28, 2017

Researchers in China have developed a novel free-piston linear generator (FPLG) to recover exhaust waste heat efficiently from a vehicle engine. The FPLG can be used in a small-scale organic Rankine cycle (ORC) system and can directly convert the thermodynamic energy of working fluid into electricity. —Tian et al. Prototype FPLG.

Exhaust 186

Exhaust Waste Conversion Engine 186

Green Car Congress

NOVEMBER 13, 2020

An actuator in the exhaust system, as fitted to the first SQ5 TDI, gives the V6 a sonorous sound. This offers the advantage since exhaust gas cleaning responds more quickly. The exhaust manifold benefits from improved insulation; the exhaust gas reaches the optimum temperature more quickly after a cold start.

Audi 269

Audi Diesel Exhaust Gas-Electric 269

Green Car Congress

FEBRUARY 11, 2023

Volvo Trucks has supplied CEMEX with its first fully electric and zero exhaust emission heavy-duty concrete mixer truck. The Volvo FMX electric heavy-duty truck can complete a full day’s work with a single top-up charge during the regular break.

Volvo 243

Volvo Fully Electric Electrical Electric 243

Electrek

APRIL 6, 2023

Riding mowers have long been the tool of choice for larger yards, and have also long been a gas-guzzling and maintenance-ridden machine. It can cut up to three acres on a single charge and doesn’t have any noisy motors, smelly exhaust, or troubling maintenance to take care of.

Gas-Electric 84

Gas-Electric Oil Green Gas 84

Green Car Congress

DECEMBER 14, 2020

Wear and tear from brakes, tires and road surfaces will soon overtake car exhaust fumes as the leading source of fine particles released into the air by road traffic, according to a new OECD report. Heavy electric vehicles with long-distance batteries could compound the problem even as they slash emissions from engine exhaust.

Exhaust 300

Exhaust Parts Emissions Transportation 300

Green Car Congress

FEBRUARY 24, 2021

Vitesco Technologies, a leading international supplier of advanced powertrain technologies and electrification solutions, is now making electrical catalyst heating available in high-voltage hybrid vehicles as well. Possible examples include electric roll stabilization or the electric steering assistance, Reich added.

DC 221

DC Convert Emissions Hybrid 221

Green Car Congress

JULY 13, 2023

The heart of the system is the SOFC stack, where chemical energy is converted into electrical energy. This hotbox is combined with an air and gas supply system, an electronic control unit, and an exhaust system to form an SOFC unit. The Bosch project is one of the first projects in Germany to receive this funding.

Fuel 360

Fuel Production Hydrogen Germany 360

Drive Electric

SEPTEMBER 19, 2022

Electric vehicles have historically received a bad reputation for concerns around safety. Issues like thermal runaway, electrocution, and reports of inextinguishable fires plagued the pioneering electric vehicles. Useful terms: Internal Combustion Engine Vehicle (ICEV) and Electric Vehicle (EV). In fact, EVs have just 25.1

Gas-Electric 98

Gas-Electric Electric Vehicles Gas Powered 98

Green Car Congress

JANUARY 17, 2023

Rolls-Royce has conducted successful tests of a 12-cylinder gas variant of the mtu Series 4000 L64 engine running on 100% hydrogen fuel. For several months, the mtu gas engine has been undergoing bench testing and continuous improvement in terms of efficiency, performance, emissions and combustion using 100% hydrogen as fuel.

Hydrogen 434

Hydrogen Engine Gas-Electric Installation 434

Green Car Congress

SEPTEMBER 30, 2010

Jaguar has unveiled the C-X75 concept, an extended range electric vehicle that uses twin gas micro-turbines from Bladon Jets to power two switched reluctance generators from SR Drives. The driver and passenger are seated ahead of a sealed airbox that houses the micro gas-turbines. Earlier post.) C-X75 powertrain. C-X75 airflow.

Extended Range 371

Extended Range Gas-Electric Gas Electric Vehicles 371

Green Car Congress

NOVEMBER 30, 2020

An electrically driven compressor for precise exhaust gas recirculation is also used. Then we modify the timing and pressure of the injection, among other things, and look at exhaust emission values and fuel consumption. This is done via exhaust gas recirculation (EGR). —Patrik Soltic.

Engine 410

Engine Fuel Exhaust Gas-Electric 410

Green Car Congress

SEPTEMBER 12, 2013

Consumption measurements of the dual-fuel natural gas-diesel engine as a function of speed and load. Researchers at ETH Zürich have developed a light-duty hybrid electric vehicle featuring a dual-fuel natural gas-diesel engine. Source: Ott et al. Click to enlarge. The dual-fuel engine can also serve in a non-hybrid application.

Gas-Electric 239

Gas-Electric Diesel Gas Light 239

Green Car Congress

OCTOBER 23, 2012

To date, exhaust gas has generally only been used if it was hundreds of degrees Celsius hot. For example, the gas turbines in natural gas power plants produce exhaust gas that is used to generate steam for the operation of a steam turbine.

Exhaust 231

Exhaust Waste Industry Industrial 231

Green Car Congress

FEBRUARY 20, 2019

Volvo Trucks delivered its first all-electric vehicles on 19 February: a refuse truck to waste and recycling company Renova, and a distribution truck to the logistics company DB Schenker and partner haulier TGM, operating in Sweden. The Volvo FL Electric trucks are part of a pre-series developed in collaboration with selected customers.

Volvo 305

Volvo Electric Electrical Sweden 305

Green Car Congress

OCTOBER 22, 2020

The new VW Golf is now also available in certain markets with natural gas drive: the Golf TGI is equipped with a 1.5-liter liter four-cylinder engine with 96 kW / 130 PS and three natural gas fuel tanks. The tanks are integrated into the underbody and permit a range of around 400 kilometers (WLTP) in pure natural gas mode.

Gas 415

Gas Available Gasoline-Electric Gas-Electric 415

Green Car Congress

OCTOBER 27, 2022

Westport’s HPDI fuel system technology enables heavy-duty trucks to operate on natural gas with the same power, torque, efficiency, and performance as diesel engines. Scania’s engine fulfils the strictest exhaust emission requirements with low fuel consumption and high torque. H2 HPDI operates the system with hydrogen.

Hydrogen 243

Hydrogen Exhaust Diesel Engine 243

Green Car Congress

SEPTEMBER 11, 2020

Freight operator Dependable Highway Express (DHE) has received two Volvo VNR Electric trucks—the first battery-electric Class 8 trucks to join DHE’s fleet. The electric trucks will be added to DHE’s existing fleet of more than 500 Volvo trucks operating across North America. Earlier post.).

Volvo 307

Volvo Fleet North America California 307

Green Car Congress

APRIL 8, 2022

For example, the geometry of the piston recess, the injection nozzle design and the parameters of the cylinder head relevant for gas exchange were subject to an extensive optimization process. An electrical actuator enables characteristics map-controlled use of the pressure-reducing valve. PowerShift Advanced and Top Torque.

Mercedes 435

Mercedes Diesel Oil Exhaust 435

Green Car Congress

NOVEMBER 20, 2018

will add 1,000 Chanje V8100 electric delivery vehicles to its fleet. The purpose-built electric vehicles will be operated by FedEx Express for commercial and residential pick-up and delivery services in the United States. FedEx has been using all-electric vehicles as part of its pickup-and-delivery fleet since 2009. FedEx Corp.

Vehicles 281

Vehicles Electric Electrical Fleet 281

Green Car Congress

MARCH 30, 2021

Schaeffler has secured a volume production order to supply electric motors to a key manufacturer in the commercial vehicle sector, starting in 2023. The energy recovered is then used to power on-board systems, especially new exhaust gas treatment systems, thereby helping vehicle fleets to meet NO x and CO 2 reduction targets.

Motors 221

Motors Motor Motoring Commercial 221

Green Car Congress

NOVEMBER 10, 2019

Combustion exhaust is directed to the fuel cell, which produces power while capturing and concentrating carbon dioxide for permanent storage. Laboratory tests indicated that applying carbonate fuel cells to natural gas power generation could capture carbon dioxide more efficiently than current, conventional CCS technology.

Carbon 360

Carbon Fuel Exhaust Energy 360

The Truth About Cars

MARCH 13, 2024

It was easy to make fun of Dodge and the “fake” exhaust it chose to employ on the new Charger EV, but it’s no longer the only one trying to capture the thrill of a performance gas engine with a silent electric powertrain underneath. That said, GM hasn’t had the smoothest rollout with its other electric models.

Cadillac 104

Cadillac Concept Tax Credit Escalade 104

Teslarati

FEBRUARY 24, 2024

Electric vehicles (EVs) don’t make nearly as much noise as vehicles with gas engines, though one automaker is looking to simulate the sound of a gas vehicle in one of its upcoming EVs. Dodge announces RAM Revolution reveal and hints at other EVs What are your thoughts?

Dodge 126

Dodge Engine Exhaust Gas-Electric 126

Green Car Congress

MARCH 13, 2022

Able to convert waste heat directly into electrical power, the E-PowerPack uses Organic Rankine Cycle (ORC) technology to reduce ship fuel consumption and CO 2 emissions. Where heat pumps use electrical power to create thermal energy for various purposes, an ORC system uses heat energy to generate electricity. Basic ORC concept.

Waste 448

Waste Mariner Gas-Electric Fuel 448

Green Car Congress

FEBRUARY 4, 2011

Researchers from the Center for Energy and Processes (CEP), MINES ParisTec, and Renault are exploring the non-catalytic reforming of diesel fuel with diesel engine exhaust gas (i.e. An alternative to the catalytic exhaust gas reforming of diesel fuel method is presented in this paper and consists of using an NTP torch.

Exhaust 199

Exhaust Gas Diesel Gas-Electric 199

Green Car Congress

MARCH 29, 2017

Ascend Energy, in collaboration with solid oxide fuel cell manufacturer Atrex Energy , released the results of a joint project to demonstrate a newly developed tubular solid oxide fuel cell (SOFC) in an electric all-terrain vehicle (ATV). A hybrid electric-type vehicle would require $7.50 Ascend worked with Tructronics Inc.,

Gas-Electric 150

Gas-Electric Energy Gas Fuel 150

Electrek

JANUARY 6, 2022

Pure Watercraft has unveiled the first fruits of its collaboration with General Motors at CES 2022, and it’s a Pure-branded, “affordable luxury” electric pontoon boat that offers silent running, smooth acceleration, and dramatically reduced maintenance – without exhaust gas and oil leaks ruining the water for everyone.

GM 144

GM General Motors Exhaust Maintenance 144