Green Car Congress

MAY 1, 2009

A study by engineers from Mahle Powertrain Ltd and BP found strong synergy between spark ignition (SI) engine downsizing and fuel containing low-to-moderate amounts of alcohol, including ethanol and butanol. A Study of Gasoline-Alcohol Blended Fuels in an Advanced Turbocharged DISI Engine. ( O 2 (% wt). Cairns et al.

Alcohol Blend 186

Alcohol Blend Downsizing Engine Fuel 186

Green Car Congress

SEPTEMBER 12, 2012

At the 17 th Supercharging conference this week in Dresden, Controlled Power Technologies (CPT) will launch what it says is the first water-cooled electric supercharger developed for “quasi-continuous” boosting of commercial diesel engines, including those developed for off highway applications. tonnes gross vehicle weight.

Water 370

Water Engine Commercial Diesel 370

Green Car Congress

OCTOBER 2, 2014

New engines and transmission. Hyundai Motor is showcasing two new turbocharged gasoline direct injected (T-GDI) engines at the Paris Motor Show 2014. Both engines—1.0-liter liter T-GDI is the first of a new generation of small turbocharged gasoline engines, offering enhanced performance, driving pleasure and efficiency.

Downsizing 239

Downsizing Hyundai Engine Hybrid 239

Green Car Congress

MAY 11, 2011

The Sentra model was simulated through a standardized Federal Test Procedure-75 (FTP-75) drive cycle for each SSC engine design. up to 33% increase in MPG) was achievable with an SSC engine replacing the Sentra’s engine when factoring in fuel cutoff during deceleration and idle in the model.

2011 210

2011 Nissan Engine Standards 210

Green Car Congress

APRIL 20, 2010

OEM On-cost for turbocharged GDi and turbo-Diesel technologies to meet Euro 6 standards. The Delphi study assessed the technology of downsizing and turbocharging; GDI fueling and its synergies with turbocharging; and an analysis of downsized 3-cylinder versus 4-cylinder engines. Source: Kirwan et al. Click to enlarge.

Gasoline 231

Gasoline Downsizing Engine CO2 231

Green Car Congress

OCTOBER 16, 2013

As reported in a paper in ACS journal Environmental Science & Technology , the results showed that GDI technology has the potential to meet the upcoming California LEV III and US EPA Tier 3 PM mass standard of 3 mg/mi (phasing in over MY2017?2021) Credit: ACS, Maricq et al. Click to enlarge. Earlier post.) and fuel properties.

Standards 246

Standards Emissions Engine Miles 246

Green Car Congress

FEBRUARY 20, 2010

The new Polo GTI, in what Volkswagen is calling “textbook downsizing”, is powered by a new 1.4-liter The engine, which delivers 132 kW (177 hp), is coupled with a 7-speed DSG as standard. liter turbo engine—consumed 7.9 Tags: Engines Fuel Efficiency. Volkswagen is premiering the new Polo GTI.

Downsizing 231

Downsizing Fuel MPG 2006 IT 231

Green Car Congress

OCTOBER 25, 2012

Fuel mass flow comparison shows Pinnacle engine ahead at just about all points in the map. FEV performed engine mappings in a dynamometer test cell to evaluate the fuel economy of Pinnacle’s TP90 scooter engine compared to a benchmark engine (N15) from Pinnacle’s Asian OEM partner. Test engine specs. Stroke [mm].

Engine 262

Engine Fuel Fuel Economy Production 262

Green Car Congress

NOVEMBER 19, 2013

L 3-cylinder direct injection gasoline turbo engine. announced that it has newly developed the VTEC Turbo, a direct injection gasoline turbo engine family most suitable for small-to-medium-sized vehicles. engines: 2.0L 4-cylinder direct injection gasoline turbo engine. L 3-cylinder direct injection gasoline turbo engine.

Gasoline 259

Gasoline Honda Engine Downsizing 259

Green Car Congress

MAY 14, 2009

Continuing to emphasize a downsizing approach, Volkswagen presented two new engines at the at the 30 th Vienna Engine Symposium (7-8 May): the 1.2-liter liter TSI gasoline engine and the 1.6-liter Both engines will be available to order for the new Polo and the Golf this year. liter 77 kW (103 hp) TSI engine.

Downsizing 150

Downsizing Engine MPG Exhaust 150

Green Car Congress

JUNE 19, 2012

demands of very high-power diesel engines. liter diesel (N57D30S1) engine applied in the M550d xDrive, with a specific power output of 93 kW/liter (124 bhp/liter). downsized diesel engines with improved fuel economy and CO 2 emissions. —Arnd Baberg, Chief Engineer Piston Product Engineering, Federal-Mogul.

Diesel 271

Diesel Engine Light Downsizing 271

Green Car Congress

MARCH 2, 2011

This marks Toyota’s first downsizing of its HSD technology. This engineering solution targets the independent powering of the air-conditioning unit for improved full hybrid powertrain fuel economy. Introducing full hybrid technology into the B-segment presented Toyota with several unique engineering challenges.

Prius 231

Prius Downsizing Hybrid Toyota 231

Green Car Congress

FEBRUARY 10, 2010

Audi will initially offer the A1 with four engines; the two TFSI gasoline engines and the two TDI diesels cover a power range from 63 kW (86 hp) to 90 kW (122 hp). All of the engines employ direct fuel injection and turbocharging. The entry-level gasoline engine is the new 1.2 Audi offers two versions of this engine.

Audi 186

Audi Standards Engine Energy 186

Green Car Congress

JULY 25, 2013

New generation XL3 injector for GDI engines goes into production. liter GDI engine. of 8 holes) enables optimal adaptation to all engine-specific requirements. of 8 holes) enables optimal adaptation to all engine-specific requirements. Click to enlarge.

Engine 294

Engine Production Emissions Downsizing 294

Green Car Congress

MARCH 5, 2014

Among the changes in the new Juke are a new design at the front and rear with greater emphasis on both premium refinement and sporty design cues; a new downsized 1.2-liter liter turbocharged engine offering greater performance, economy and lower emissions; a revised 1.6-liter Engines and drivetrains. The existing 1.5

Nissan 255

Nissan Engine Downsizing Europe 255

Green Car Congress

MAY 8, 2013

At the recent 2013 SAE World Congress, engineers from Bosch and AVL presented papers on progress in the ACCESS project, describing the design, combustion development and controls development for a resulting 4-cylinder gasoline turbocharged direct injection (GTDI) engine with part-load HCCI capability. I4 Ecotec engine.

Fuel Economy 278

Fuel Economy Economy Fuel Engine 278

Green Car Congress

OCTOBER 5, 2012

New cam phaser for I4 engine. BorgWarner is expanding its variable cam timing (VCT) technology with a new family of cam phasers for inline-4 engines. the engine is running, VCT gives the engine designer added flexibility over a conventional fixed timing drive system. Click to enlarge. Earlier post.)

2015 231

2015 Gasoline Engine Diesel 231

Green Car Congress

DECEMBER 6, 2011

Highly efficient at low engine revolutions, electric superchargers make it possible to downsize engines. When coupled with an energy recovery system, electric superchargers can be used to create a cost-competitive hybrid solution that can deliver fuel savings of up to 20% in the standard European driving cycle, Valeo said.

Power 326

Power Powered Downsizing Electric 326

Green Car Congress

APRIL 6, 2016

This trend of increasing demand for higher octane gasoline is likely driven by changes in fuel requirements for light-duty vehicles (LDV) in response to increasing fuel economy standards, which will have widespread implications for future gasoline markets, according to EIA analysts. of the LDV market by 2025.

Downsizing 150

Downsizing Gasoline Engine Design 150

Green Car Congress

DECEMBER 1, 2014

At the 2 nd International Conference Automotive 48 V Power Supply Systems , held last week in Düsseldorf, Germany, Controlled Power Technologies (CPT), a major sponsor of the event, together with leading car makers and Tier 1 suppliers, argued the need for an internationally agreed 48V electrical standard. Earlier post.).

Standards 257

Standards International Vehicles Hybrid 257

Green Car Congress

MARCH 14, 2010

liter V8 biturbo engine. liter V8 biturbo engine with a peak output of up to 420 kW (563 hp) and maximum torque of up to 900 N·m (663 lb-ft) from its higher performance variant for entry into the Mercedes-Benz/AMG lineup this summer. kg/hp for the basic engine, and 0.39 Click to enlarge. AMG has developed a 5.5-liter

Downsizing 186

Downsizing Standards Fuel Mercedes 186

Green Car Congress

APRIL 10, 2014

ExxonMobil, Corning and Toyota have collaborated to develop an Onboard Separation System (OBS) to optimize gasoline engine efficiency and performance. In a paper on the OBS presented at the SAE 2014 World Congress, the researchers suggested that potential applications include downsizing to increase fuel economy by ?10% Background.

Gasoline 316

Gasoline Engine Toyota Fuel Economy 316

Green Car Congress

MAY 6, 2013

The new MY2014 Mercedes-Benz Sprinter van for the US now features a 2.1L, 4-cylinder diesel with a t-speed automatic transmission as standard. liter four-cylinder diesel engine produces 161 hp (120 kW) and 265 lb-ft (359 N·m) of torque at 1,400-2,400 rpm. The engines attain both a high specific power output and high torque.

Diesel 306

Diesel 2014 Standards Exhaust 306

Green Car Congress

APRIL 28, 2012

Test results from that supplier have demonstrated potential fuel-saving, engine down-sizing and/or down-speeding opportunities without adversely affecting performance and drivability. band, particularly at low engine speeds. manufacturers can utilize smaller, more efficient engines with no loss in. V6 engine.

Downsizing 304

Downsizing Engine 2008 Design 304

Green Car Congress

FEBRUARY 4, 2013

During its recent Innovation Day presentations ( earlier post ), PSA Peugeot Citroën announced that it will commercialize high-efficiency gasoline engines featuring dedicated exhaust gas recirculation (D-EGR), derived from a collaborative program with SwRI in the US. PSA concept D-EGR engine. PSA has filed for two patents on its work.

Gasoline 268

Gasoline 2018 Engine Commercial 268

Green Car Congress

JUNE 7, 2010

In terms of powertrain technologies, Renault focused on the introduction of new technologies for internal combustion engines and conventional transmissions, as well as outlining its commitment to electric powertrains. Select Engines. dCi engines. Specific engine-mapping aimed at reducing fuel consumption and CO 2 emissions.

Environment 230

Environment Engine 2010 Parts 230

Green Car Congress

APRIL 17, 2014

In a presentation at the SAE 2014 High Efficiency IC Engine Symposium and then in a paper given at SAE 2014 World Congress, Mark Sellnau, Engineering Manager, Delphi Advanced Powertrain, reported that Brake Specific Fuel Consumption for the 1.8L Earlier post , earlier post.). Background. Earlier post.) DOE UFEV program targets.

Gasoline 304

Gasoline Engine Fuel Wisconsin 304

Green Car Congress

JUNE 23, 2014

MiGTDI engine. Emission standards (g/mi). Ford’s approach to the project was to engineer a comprehensive suite of gasoline engine systems technologies, including: Aggressive engine downsizing in a mid-sized sedan from a large V-6 to a small I-4. Source: Ford. Click to enlarge. Earlier post.). Earlier post.).

Fuel Economy 247

Fuel Economy Economy Ford Engine 247

Green Car Congress

JUNE 27, 2017

The all-new 2018 Volkswagen Tiguan—the second-generation of the vehicle—is powered by the latest version of the EA888 four-cylinder engine, the 2.0L This is the only engine/transmission combination available in the Tiguan in the US. TSI EA888 Gen3 B-Cycle (Budack-cycle, earlier post ), coupled with an 8-speed automatic.

2018 314

2018 Engine SUV MPG 314

Green Car Congress

NOVEMBER 16, 2011

The US Environmental Protection Agency (EPA) and the US Department of Transportation (DOT) formally unveiled their joint proposal to set stronger fuel economy and greenhouse gas pollution standards for Model Year 2017-2025 passenger cars and light trucks. EPA’s proposed GHG standards, which are. mpg US (5.87 mpg US (5.87 improvements.

Fuel Economy 338

Fuel Economy EPA Economy MPG 338

Green Car Congress

MAY 14, 2012

France-based Scaleo chip has introduced AMEC (Advanced Motor Events Control), a technology for internal combustion engines and electric motors control. AMEC—a flexible microcontroller interface for engine control—will be first available in OLEA, Scaleo chip’s new family of microcontrollers optimized for powertrain systems.

Motoring 218

Motoring Motor Motors International 218

Green Car Congress

NOVEMBER 7, 2013

Ricardo and JAC, one of China’s largest vehicle manufacturers, are working together on thermal systems engineering for passenger car applications. As a part of the project, Ricardo is also providing technology transfer in the form of collaborative working and training to JAC engineers both in China and at Ricardo sites in the UK.

Engine 186

Engine Downsizing Vehicles Asia 186

Green Car Congress

NOVEMBER 8, 2011

those which do not favor one technology over another through consumer incentives, federal subsidies, testing standards or technology-specific credits. From a “well-to-wheel” perspective, high efficient gasoline and diesel engines are nearly as energy efficient as any technology available.

Standards 247

Standards Transportation Fuel Economy MPG 247

Green Car Congress

APRIL 14, 2011

The system also reduces engine-out NO x by more than 99%.the Efforts on combustion initiation in pre-chamber cavities in spark ignition engines reaches back to the 2-stroke Ricardo Dolphin engine in the first part of the twentieth century. Background. Since then, many variants have been developed. The new study.

Fuel Economy 210

Fuel Economy Economy Engine Fuel 210

Green Car Congress

NOVEMBER 4, 2011

Port assisted direction injection (PDI)—a dual injection system for combining the benefits of port fuel injection (PFI) and direct injection (DI), and enabling a dual fuel system approach for high compression ratios and extreme downsizing on boosted engines. Emitec is heading up the work on aftertreatment design and improvements.

Fuel Economy 218

Fuel Economy Gasoline Light Engine 218

Green Car Congress

NOVEMBER 8, 2016

Specifically, devices produced should show automotive application readiness through passing full or partial qualification specifications or standards at high device production yields. Fuel Efficiency Improvement Technologies for Conventional Stoichiometric Gasoline Direct Injection Multi-Cylinder Internal Combustion Engine.

Engine 253

Engine Fuel Hydrogen Battery 253

Green Car Congress

APRIL 2, 2010

The footprint-based standard CO 2 curves for cars (left) and trucks (right). Each manufacturer will have its own fleet-wide standard which reflects the vehicles it chooses it produce. system leakage) and indirect CO 2 emissions related to the increased load on the engine. Source: EPA. Click to enlarge. mpg US (6.9 mpg US (EPA).

EPA 236

EPA Standards Light PHEV 236