Green Car Congress

FEBRUARY 24, 2023

Supported by a grant from the Niche Vehicle Network, supported by the Department for Transport and Innovate UK, the project will adapt the design of the Yamaha Tricity 300 to replace its combustion engine with a fully electric powertrain with fast-charging capability and a targeted 100 mile operating range.

Motorcycles 397

Motorcycles Fully Electric Concept Electric Motorcycles 397

Green Car Congress

NOVEMBER 8, 2016

Fuel Efficiency Improvement Technologies for Conventional Stoichiometric Gasoline Direct Injection Multi-Cylinder Internal Combustion Engine. A turbocharging system is needed that provides high boost pressure from a single turbocharger over an engine speed range of approximately 1000 rpm to 5000 rpm.

Engine 253

Engine Fuel Hydrogen Battery 253

Green Car Congress

JUNE 22, 2013

VCR 4-cylinder engine (projected data) from a 2011 report by Envera. All three engine BSFC curves correspond to an engine speed of 2000 rpm.Click to enlarge. The new engine will achieve high efficiency using the Atkinson Cycle with an 18:1 compression ratio, combined with aggressive engine downsizing.

Engine 207

Engine Eaton Fuel Economy Downsizing 207

Green Car Congress

DECEMBER 10, 2009

Comparison of fuel consumption of Omnivore, homogeneous Gasoline Direct Injection (GDI) and Spray-Guided GDI engines. The first testing phase of Lotus Engineering’s Omnivore variable compression ratio, flex-fuel direct injection two-stroke engine ( earlier post ) has been successfully completed on gasoline. Click to enlarge.

Fuel Economy 218

Fuel Economy Engine Light Fuel 218

Green Car Congress

JUNE 25, 2012

engine and 6-speed transmission. XL Hybrids’ hybrid electric powertrain is a low-cost, low-risk, bolt-on, post-transmission parallel hybrid technology designed for Class 1–3 commercial vehicles that integrates seamlessly with the conventional internal combustion engine and transmission. We don’t touch the warranty.

Hybrid 330

Hybrid Fuel Lithium Ion Downsizing 330

Green Car Congress

SEPTEMBER 28, 2009

GM’s second-generation fuel-cell system (engineer included for scale.) The new system, where we have adopted a pretty radical change in the architecture itself, downsizes dramatically, takes 100 kg of the mass out, and takes the size down to half of that of the Equinox. Click to enlarge. The new second-generation system is to the left.

GM 262

GM 2015 Fuel Engine 262

Green Car Congress

MAY 1, 2012

Delphi Automotive has developed a common rail fuel system technology for heavy-duty diesel engines that combines proven hardware with an innovative architecture, allowing vehicle manufacturers to meet Euro VI emissions standards without significant modification to their base engines. New high pressure heavy duty common rail systems.

Engine 199

Engine Light Diesel 2000 199

Green Car Congress

JANUARY 22, 2010

This investment is part of our ongoing strategy to put the UK at the forefront of low carbon vehicle technology. We are funding innovative projects in a number of key areas which include internal combustion engine technologies, energy storage and management, lightweight structures and new propulsion technologies.

Carbon 225

Carbon Li-ion Downsizing Gas 225

Green Car Congress

JANUARY 19, 2021

A team of Penn State engineers has demonstrated a thermally modulated lithium iron phosphate (LFP) battery to offer an adequate cruise range per charge that is extendable by a 10-minute recharge in all climates, essentially guaranteeing EVs that are free of range anxiety. A paper on their work is published in Nature Energy.

Market 305

Market Battery Batteries Charging 305

Green Car Congress

OCTOBER 4, 2009

During his presentation at the recent California Air Resources Board (ARB) ZEV Technology Symposium, Tatsuaki Yokoyama, from Toyota Motor Engineering & Manufacturing North America, said that Toyota aimed to reduce the cost of fuel cell vehicles to 1/10 of the current level by design and materials improvement by commercialization in 2015.

2015 315

2015 Toyota Commercial Fuel 315

Green Car Congress

SEPTEMBER 29, 2011

At 48 volts, a VTES electric supercharger will transform 7kW of battery power into a highly boosted charge of air for downsized gasoline and diesel engines. In other words adding a useful 42kW boost for low speed overtaking and hill climbs. —Guy Morris, CPT’s engineering director and chief technical officer.

Volt 207

Volt Hybrid Downsizing Lead Acid 207

Green Car Congress

SEPTEMBER 24, 2009

Delphi is highlighting new developments in the area of fuel injection systems, ignition, valve train and ancillary systems for improving fuel consumption and lowering CO 2 emissions from spark ignition engines without what it calls the cost and risk of different technologies. Delphi CNG injector. Click to enlarge.

Engine 186

Engine Fuel Gasoline-Electric Gasoline 186

Green Car Congress

JUNE 18, 2013

Only the diesel engine will achieve this in the compact class, but the gasoline engine will come close. In order to further reduce its CO 2 emissions in this vehicle class, the gasoline engine will require a low-cost, basic hybrid solution. In addition, performance is increasing relative to engine size.

Future 291

Future Gasoline-Electric Vehicles Gasoline 291

Green Car Congress

MARCH 4, 2009

Fiat expects that Multiair, with direct control of the air through the intake engine valves without using the throttle, can help reduce fuel consumption by up to 10% for turbocharged or naturally aspirated gasoline engines. Pollutant emissions are likewise reduced through combustion control.

Downsizing 210

Downsizing Gasoline Fuel Economy Engine 210

Green Car Congress

SEPTEMBER 30, 2015

Anhui Jianghuai Automobile Group Co Ltd (JAC) and Ricardo are collaborating on a project to develop the Ricardo HyBoost concept ( earlier post )—a combination of low-cost technologies to deliver improved performance and fuel economy which featured recently in the Ricardo Centenary celebrations —into volume production on a JAC vehicle.

Fuel Economy 150

Fuel Economy Economy Concept Fuel 150

Green Car Congress

JUNE 24, 2016

By combining its extensive experience in main drive and auxiliary drive transmissions, Torotrak has designed a variator concept with ratio spread of up to 12, operated by a low cost actuation system. the Torotrak V-Charge. Fuller said that electric vehicles could also benefit from the latest variator developments.

Low Cost 225

Low Cost Downsizing Congress Fuel Economy 225

Green Car Congress

FEBRUARY 25, 2014

This 17-tonne production excavator was installed with the flywheel unit and tested over a repeated materials handling cycle at a range of different engine speeds. —Ricardo VP of Innovation David Rollafson. Click to enlarge.

Energy Storage 225

Energy Storage Las Vegas Energy Production 225

Green Car Congress

AUGUST 20, 2013

Blending 25-50% of this low-temperature ethanol reformate with ethanol or E85 fuels enables dilute engine operation, resulting in substantial improvements in fuel economy and emissions. Because exhaust-driven reforming uses only waste engine heat, it avoids this efficiency hit, the authors note.

Fuel Economy 230

Fuel Economy Exhaust Economy Fuel 230

Green Car Congress

AUGUST 14, 2017

The extreme valve temperatures experienced on today’s highly boosted downsized engines can lead to reduced valve fatigue life and critical valve guide and stem seal temperatures, resulting in the need for expensive valve steel alloys.

Engine 150

Engine Emissions Exhaust Sodium 150

Green Car Congress

JANUARY 27, 2016

The T-Hybrid (based on a Kia Optima) ( earlier post ) and the ADEPT (based on a Ford Focus) ( earlier post ) both utilize an advanced 48V lead-carbon battery system with bolt-on electrical components that allow for significant engine-downsizing without loss in performance. liter engine the performance of a 1.8

Emissions 150

Emissions Hybrid CO2 Downsizing 150

Green Car Congress

APRIL 23, 2017

Researchers at the University of California, Riverside’s Bourns College of Engineering have used waste glass bottles and a low-cost chemical process to fabricate nanosilicon anodes for high-performance lithium-ion batteries. Coating the silicon nanoparticles with carbon to improve their stability and energy storage properties.

Li-ion 150

Li-ion Waste Lithium Ion Battery 150

Green Car Congress

AUGUST 1, 2016

The US Department of Energy (DOE) will award up to $7 million in project funding to accelerate the introduction of affordable, scalable, and sustainable high-performance fuels for use in high-efficiency, low-emission engines as part of the Co-Optimization of Fuels and Engines (Co-Optima) initiative. Earlier post.).

Engine 150

Engine Fuel Emissions Pollution 150

Green Car Congress

NOVEMBER 8, 2019

Thus a compact and cost-effective battery that is capable of high charge and discharge power levels relative to its storage capacity (high C rates) is desirable. As there were no suitable low-cost, compact batteries able to deal with the necessary recharge and discharge cycles involving high currents, MAHLE Powertrain developed its own.

Volt 170

Volt Battery Batteries Hybrid 170

Green Car Congress

FEBRUARY 18, 2014

This common core also provides greater confidence in the robustness of prototypes, while minimizing the cost of variants further supports the development of 48V systems. SR machines are ideally suited to this concept of low cost development, while reducing the cost of production components.

Congress 236

Congress Hybrid Exhaust Gas-Electric 236

Green Car Congress

JUNE 11, 2016

The SIA conference was focused on clean compression-ignition engines of the future. Future RDE emissions legislation and fleet average CO 2 targets represent a challenge for automakers wishing to provide cost-effective light duty diesel vehicles. liter diesel engine.

Light 150

Light Diesel Price Exhaust 150

Green Car Congress

JULY 31, 2015

Aeristech’s 48v eSupercharger has already been demonstrated by MAHLE Powertrain UK in a D-segment appraisal vehicle using its downsized turbocharged 1.2 liter, 3-cylinder gasoline engine. The engine achieved 32.9 At low speed (1250 rpm), the eSupercharger achieved 28.6 Our system can deliver over 2.5

Gasoline-Electric 150

Gasoline-Electric Electric Electrical Engine 150

Green Car Congress

AUGUST 16, 2016

will design and develop a new more-efficient engine and advanced drivetrain and vehicle technologies. will design and develop a vehicle and powertrain with electrified engine components that can enable higher engine efficiency and a significantly more aerodynamically reengineered cab. Texas A&M Engineering Experiment Station.

Vehicles 150

Vehicles Plug-in Lithium Ion Universal 150

Cars That Think

NOVEMBER 7, 2022

Due to their low cost, thin form factor, and pliability, flexi discs became the medium of choice for magazine publishers who wished to supplement articles with audio content. Since 1995, LHL has been the home of the 360,000 volumes formerly housed at the Engineering Societies Library , including extended runs of most IEEE journals.

Kansas City 101

Kansas City Kansas Missouri Downsizing 101

Green Car Congress

JULY 17, 2015

The PHEV (Plug-in Hybrid Electric Vehicle), a subset of the electric car, combines a primary electric motor with a much smaller back-up engine fueled with a hydrocarbon/biofuel mix. (In Engineering Advantages of PHEV. Engineering Advantages of the PHEV. This engineering solution allows versatility. Table of Contents.

PHEV 150

PHEV Plug-in Renewable Energy 150

Cars That Think

MARCH 12, 2023

Extrapolating from company targets, a future compact-size Lucid—think the size of Tesla Model 3 or Model Y—could decisively downsize its battery without sacrificing useful range. That becomes a low-cost way to generate big improvements in pack density and bolster the mileage of a vehicle,” Castillloux says.

Battery 98

Battery Batteries Supplies GM 98

Baua Electric

MAY 17, 2024

New, three-cylinder fuel-sipping engine One of the key recipients of this investment is the development of the new 1.2-litre litre Z-series powertrain, which now features a three-cylinder layout for the petrol engine, christened Z12E, a downsize from the outgoing 1.2-litre, litre, four-cylinder, K12C unit.

Suzuki 52

Suzuki India South Africa Petrol 52

Charged EVs

AUGUST 4, 2022

Steven Kaye: ONE’s anode-free cell advantages include high energy density (thin lithium metal anode), low cost (no anode present during cell assembly, low-cost liquid electrolyte), and abundant raw materials (mostly manganese, zero cobalt). The challenge is that anode-free cells still have low cycle life.

Miles 70

Miles Range DC Battery 70

Tony Karrer Delicious EVdriven

APRIL 21, 2009

Honda Sees PHEVs as having "unnecessary fuel engine and fuel tank;" promises all-electrics "assuming we can come up with a really high-performing battery that we are working on currently." The F6 DM uses ferrous batteries, with no lithium content, that BYD says are high-energy density and low cost. See Chevy Volt for latest.

Plug-in 45

Plug-in Plug Hybrid Lithium Ion 45