Green Car Congress

MAY 1, 2009

A study by engineers from Mahle Powertrain Ltd and BP found strong synergy between spark ignition (SI) engine downsizing and fuel containing low-to-moderate amounts of alcohol, including ethanol and butanol. The team presented a paper on their work at the recent SAE 2009 World Congress in Detroit. Cairns et al. SAE 2009-01-0138).

Alcohol Blend 186

Alcohol Blend Downsizing Engine Fuel 186

Green Car Congress

JANUARY 2, 2018

Researchers at Tianjin University in China report that combing split injection to the Miller cycle with boost pressure can effectively decrease the knock tendency and increase the engine torque in a downsized spark-ignition engine. Their paper is published in the journal Fuel. —Wei et al. L and a compression ratio of 10:1.

Downsizing 186

Downsizing Engine Fuel Economy E6 186

Green Car Congress

DECEMBER 6, 2011

Highly efficient at low engine revolutions, electric superchargers make it possible to downsize engines. version of the vehicle but with fuel economy and CO 2 emissions approaching those of a Prius. HyBoost shows comparable performance to the conventional 2.0L Earlier post.).

Power 326

Power Powered Downsizing Electrical 326

Green Car Congress

APRIL 14, 2011

Results of this study showed that the pre-chamber jet ignition combustion system roughly matches HCCI fuel economy across both NEDC and FTP drive cycles, with a 13% improvement in fuel economy recorded over the baseline stoichiometric (λ=1) spark ignition combustion system. The new study. liter) GM engine.

Fuel Economy 210

Fuel Economy Economy Engine Fuel 210

Green Car Congress

OCTOBER 16, 2012

The 170 hp engine has been developed with fuel economy, high low-end torque and elasticity in mind, while the performance of the 200 hp unit makes it the benchmark in its class. The new engine family comprises a 1.6 The roll-out of the new engine family—developed in Ruesselsheim, Germany—will begin in early 2013. Turbocharging.

Gasoline 350

Gasoline Engine Fuel Power 350

Green Car Congress

NOVEMBER 16, 2011

The US Environmental Protection Agency (EPA) and the US Department of Transportation (DOT) formally unveiled their joint proposal to set stronger fuel economy and greenhouse gas pollution standards for Model Year 2017-2025 passenger cars and light trucks. L/100km), if the vehicles were to meet this CO 2 level all through fuel economy.

Fuel Economy 338

Fuel Economy EPA Economy MPG 338

Green Car Congress

MARCH 7, 2012

liter i-DTEC engine in the new Civic will deliver CO 2 emissions of 95 g/km, according to Honda Motor Europe’s President, Manabu Nishimae, in his presentation at the Geneva Motor Show. By downsizing from the outgoing 2.2L With these engines we aim to be Number 1 in fuel economy in each sector within 3 years. Click to enlarge.

Honda 299

Honda Emissions Diesel CO2 299

Green Car Congress

JUNE 23, 2014

Ford’s approach to the project was to engineer a comprehensive suite of gasoline engine systems technologies, including: Aggressive engine downsizing in a mid-sized sedan from a large V-6 to a small I-4. Cycle-based CAE analysis of fuel economy contribution of critical technologies. Earlier post.). The approach. Electric TiVCT system.

Fuel Economy 247

Fuel Economy Economy Ford Engine 247

Green Car Congress

MAY 14, 2009

Continuing to emphasize a downsizing approach, Volkswagen presented two new engines at the at the 30 th Vienna Engine Symposium (7-8 May): the 1.2-liter Downsizing is rigorously being developed in the volume segments with the 1.2 Click to enlarge. liter TSI gasoline engine and the 1.6-liter liter TDI diesel. Earlier post.).

Downsizing 150

Downsizing Engine MPG Exhaust 150

Green Car Congress

MAY 9, 2012

Researchers from Southwest Research Institute (SwRI) and Eaton have demonstrated the application of downspeeding and supercharging a diesel vehicle, in conjunction with optimizing transmission gear ratios and the shift schedule, to deliver a greater improvement in fuel economy than a downsped and turbocharged configuration.

Fuel Economy 199

Fuel Economy Economy Fuel Eaton 199

Green Car Congress

APRIL 22, 2013

downsized, turbocharged) gasoline engine, as operating an engine with higher compression ratios at low load can increase fuel economy compared to operating an engine with fixed compression ratio. Use of a variable compression ratio (VCR) could be one technology approach to reducing fuel consumption in highly boosted (e.g.,

Fuel Economy 218

Fuel Economy Economy Fuel Downsizing 218

Green Car Congress

NOVEMBER 4, 2011

Hakan Yilmaz, Global Technology Management, Gasoline Systems, for Bosch presented an overview of and update on the project at the 2011 DEER conference in Detroit in October. Two-stage boost—a small supercharger for HCCI, and a regular turbocharger for downsizing. HCCI range extension with boosting. Source: Bosch.

Fuel Economy 218

Fuel Economy Gasoline Light Engine 218

Green Car Congress

DECEMBER 11, 2009

Small displacement engines offer excellent CO 2 and fuel economy benefits; they have lower parasitic losses and operate more efficiently under part load conditions. Small engines can also be turbocharged to deliver comparable torque and power to a larger naturally aspirated engine. Low Carbon Vehicle Partnership Technology Challenge.

Downsizing 191

Downsizing Power Powered Exhaust 191

Green Car Congress

FEBRUARY 12, 2014

Much further testing and optimization remains to be done, Kirby noted. Background. Magnomatics was founded in 2006 by a group of engineers from the University of Sheffield (UK) to commercialize magnetic gearing and motor technology developed there.

Fuel Economy 270

Fuel Economy Hybrid Economy San Diego 270

Green Car Congress

APRIL 6, 2017

Improving battery power to such as level would further enable hybridization to near-HEV levels as well as engine downsizing, thereby enabling fuel economy improvements beyond the current 10-15% MHEV limit. To address these needs, the A123 team presented a high-power, lithium-iron-phosphate chemistry with excellent rate capabilities.

Battery Powered 284

Battery Powered Fuel Economy Hybrid Power 284

Green Car Congress

JUNE 14, 2011

Based on the results of the study, CAR believes the economic risk to the auto industry connected to mandating permanent fuel economy standards in the long run is “ very serious ” The group recommends periodic review to assess the rate of technology development and cost reduction of advanced technologies leading up to 2025.

Fuel Economy 199

Fuel Economy Economy Auto Industry Standards 199

Green Car Congress

APRIL 10, 2014

In a paper on the OBS presented at the SAE 2014 World Congress, the researchers suggested that potential applications include downsizing to increase fuel economy by ?10% increase in fuel economy, according to their work; 8.5% These results were intriguing. —Partridge et al. The OBS system. liter engine.

Gasoline 316

Gasoline Engine Toyota Fuel Economy 316

Green Car Congress

OCTOBER 10, 2012

Their paper was presented at the ASME Internal Combustion Engine Division 2012 Fall Technical Conference by Marcello Canova, assistant professor at OSU; lead author was Philipp Skarke, from the University of Stuttgart Institute for Internal Combustion Engines and Automotive Engineering. The OSU EcoCAR PHEV powertrain.

Waste 312

Waste PHEV Fuel Exhaust 312

Green Car Congress

APRIL 19, 2013

The team presented a paper on their work at the 2013 SAE World Congress in Detroit. Ford engineers also presented two other papers evaluating the effects of low to mid-level ethanol blends in spark-ignited engines at the conference. Downsizing/downspeeding. Volumetric fuel economy. —Stein et al.

Engine 253

Engine Fuel Ford Future 253

Green Car Congress

APRIL 24, 2012

The company presented these latest test results in a paper at the SAE 2012 World Congress in Detroit. There is no ISFC improvement at high load. The results represent a light-load indicated efficiency improvement of 15-30% (up to 40.9%). Net indicated efficiency of the Pinnacle Opposed-Piston engine, CR = 15:1, 87 Octane. Source: Pinnacle.

Light 304

Light Fuel Economy Engine Fuel 304

Green Car Congress

OCTOBER 11, 2013

The Automobile Division of the Institution of Mechanical Engineers has awarded its Prize for the Environment to Ricardo, Ford Motor Company, Controlled Power Technologies and Valeo engineers for their paper HyBoost—An Intelligently Electrified Optimized Downsized Gasoline Engine Concept. Earlier post.). Earlier post.)

Engine 210

Engine Downsizing Lead Acid Automobile 210

Green Car Congress

OCTOBER 2, 2014

The unit features a six-hole GDI injector, pressured to a higher-than-average 200 bar, securing a clean combustion and improving fuel economy and emissions to fulfill Euro 6c emission standards, three years ahead of their introduction in 2017.

Downsizing 239

Downsizing Hyundai Engine Hybrid 239

Green Car Congress

APRIL 14, 2010

The SuperTurbo’s supercharger function enhances the transient response of a downsized and turbocharged engine, and the turbo-compounding function offers the opportunity to extract the available exhaust energy from the turbine rather than opening a waste gate. Downsizing from a 3.2L improved fuel economy 17%, and downsizing from a 4.2L

Waste 218

Waste Engine Downsizing Hybrid 218

Green Car Congress

DECEMBER 17, 2015

The engine should yield fuel efficiency gains of more than 50% compared to a downsized, turbo-charged gasoline direct injection engine, while reducing the overall cost of the powertrain system, said Fabien Redon, Vice President, Technology Development at Achates Power. Earlier post.) earlier post ). Earlier post.). Fabien Redon.

Downsizing 150

Downsizing Engine Fuel Gasoline 150

Green Car Congress

SEPTEMBER 13, 2010

liter ELC-Hybrid to downsized 1.4L VTES + SpeedStart. CPT and AVL’s most recent work assesses the potential of a VTES equipped downsized ELC-Hybrid vehicle in combination with the CPT SpeedStart Integrated Starter Generator ( earlier post ) and the UltraBattery. Click to enlarge.

VRLA 210

VRLA Hybrid Downsizing Fuel 210

Green Car Congress

OCTOBER 8, 2013

Opel presented details of its new three-cylinder 1.0-liter SIDI Turbo also delivers a 20% improvement in fuel economy compared to the 1.6-liter liter class which are engineered to meet customer demand for strong, downsized engine performance. liter SIDI turbo with 85 kW/115 hp. Click to enlarge. liter engine.

Engine 220

Engine MPG Exhaust Gasoline 220

Green Car Congress

MAY 16, 2019

In a paper presented at the 2019 Vienna Motor Symposium this week, Delphi Technologies will unveil a new 500+ bar GDi system that can reduce particulate emissions by up to 50% compared to state-of-the-art 350 bar system without expensive engine design modifications. Delphi 500+ bar GDi pump. Delphi 500+ bar GDi injector. —Walter Piock.

Emissions 257

Emissions Gasoline Fuel Exhaust 257

Green Car Congress

APRIL 23, 2012

An increase in pumping requirements for any reason carries a fuel economy penalty. Scuderi explained that “Millerizing” the Scuderi split cycle means downsizing the compression cylinder to get the over-expansion technique that is the core of the Miller approach—achieved in a convention engine by using early or late valve closing.

Engine 294

Engine Design Congress Downsizing 294

Green Car Congress

OCTOBER 5, 2011

” Bunker spent the bulk of his presentation describing the new medium- and heavy-duty fuel economy and greenhouse gas regulations from EPA and the Department of Transportation. The future that we point to [is] very conventional-looking engines.” Earlier post.) In his talk during the opening plenary, Dr.

International 265

International Future Engine EPA 265

Green Car Congress

OCTOBER 4, 2009

During his presentation at the recent California Air Resources Board (ARB) ZEV Technology Symposium, Tatsuaki Yokoyama, from Toyota Motor Engineering & Manufacturing North America, said that Toyota aimed to reduce the cost of fuel cell vehicles to 1/10 of the current level by design and materials improvement by commercialization in 2015.

2015 315

2015 Toyota Commercial Fuel 315

Green Car Congress

JUNE 24, 2016

At the 2016 International VDI Congress “Drivetrain for Vehicles” in Friedrichshafen, Germany, John Fuller, Director of Concepts & IP for Torotrak Group, presented and discussed the company’s latest advances to optimize its full-toroidal variator technology for the light vehicle market as applied in continuously variable transmissions (CVTs).

Low Cost 225

Low Cost Downsizing Congress Fuel Economy 225

Green Car Congress

OCTOBER 25, 2012

In keeping with the trend to downsizing, Hyundai has been expanding the application of Turbo Gasoline Direct Injection (T-GDI) engines. A variety of technologies were adopted to maximize fuel economy and performance of the Kappa 1.0 The Kappa 1.0 101 lb-ft), and emits less CO 2 than its original gasoline model.

Hyundai 218

Hyundai Future Gasoline Exhaust 218

Green Car Congress

APRIL 22, 2009

presented a pair of papers at the SAE 2009 World Congress describing the development of a variable compression ratio (VCR) engine enabled by a dual piston mechanism. improvement in fuel economy in operation over the Japanese 10-15 cycle. Engineers from Honda R&D Co., Kadota et al.

Honda 150

Honda Concept Engine Downsizing 150

Green Car Congress

AUGUST 10, 2009

This was reinforced during a subsequent presentation by Robert Czarnowski, of Borg Warner, on that company’s new control strategy for a dual loop EGR system to meet projected future emissions standards. We see dramatic downsizing and boosting [as] something that’s going to for gasoline engines especially. John Kirwan.

Gasoline 150

Gasoline Diesel Engine Emissions 150

Green Car Congress

AUGUST 4, 2015

This brings implementation of intelligent downsizing to more than 97% of vehicles sold by Volkswagen in the US, available across all the models on sale. Volkswagen is introducing the 1.4-liter liter EA211 four-cylinder turbocharged and direct-injection TSI engine into the Jetta range, replacing the previous naturally aspirated 2.0-liter

Engine 150

Engine Range Fuel Economy Downsizing 150

Green Car Congress

APRIL 2, 2014

The V-Charge variable drive supercharger allows smaller engines to provide the drive feel of a larger unit, enabling downsizing without compromising driveability. Earlier post.). Earlier post.). —Torotrak chief executive Jeremy Deering.

Manufacturer 225

Manufacturer Downsizing Fuel Economy Fuel 225

Green Car Congress

JUNE 22, 2013

The new engine will achieve high efficiency using the Atkinson Cycle with an 18:1 compression ratio, combined with aggressive engine downsizing. Envera specializes in the development of advanced technologies for improving automotive fuel economy. Engine downsizing is a key tool in improving fuel economy. Background.

Engine 207

Engine Eaton Fuel Economy Downsizing 207