Green Car Congress

JUNE 23, 2023

A research consortium led by Ford Research and Innovation Center Aachen is currently investigating the technical conditions under which diesel vehicles can run on dimethyl ether (DME) as an alternative fuel. With dynamic blending, even flex-fuel operation (diesel or DME/diesel) would be possible while retaining the original diesel system.

Diesel 367

Diesel Alternative Fuels Fuel Gas 367

Green Car Congress

JANUARY 3, 2022

Heavy-duty diesel vehicles using mixing controlled compression ignition (MCCI), the most common ignition and combustion strategies for heavy-duty diesel engines, contribute significantly to the emissions of GHG, oxides of nitrogen (NO x ), and particular matter (PM) and are subject to stringent emission standards. Skaggs et al.

Waste 434

Waste Diesel Renewable Convert 434

Green Car Congress

OCTOBER 8, 2022

Engineers from UNSW Sydney (Australia) have successfully converted a diesel engine to run as a dual-fuel hydrogen-diesel engine, reducing CO 2 emissions by more than 85% compared to conventional diesel. below the amount produced by the diesel powered engine. CO 2 reduction and 13.3% IMEP/efficiency increase are achieved.

Hydrogen 448

Hydrogen Diesel Fuel CO2 448

Green Car Congress

AUGUST 15, 2021

LGF is the first renewable diesel fuel project to achieve this milestone. Carbon capture and permanent geologic sequestration is no longer a hypothetical scenario for Louisiana Green Fuels—successful completion of the test well is a major milestone that’s not been achieved by any other renewable diesel project.

Renewable 353

Renewable Carbon Diesel Louisiana 353

Green Car Congress

NOVEMBER 15, 2020

For the first time, renewable raw materials are being converted to Swedish Environmental Class 1 diesel (maximum sulfur content of 10 ppm) at Preem’s refinery in Lysekil. This test process is within the conditions of the existing environmental permit and is a basis for the refinery’s conversion.

Renewable 319

Renewable Diesel Production Conversion 319

Green Car Congress

FEBRUARY 17, 2023

ULEMCo has been awarded a major fleet-wide contract by Aberdeen City Council (ACC) for its hydrogen dual-fuel utility vehicle conversions. ULEMCo’s H2ICED allows hydrogen to be mixed with diesel directly in a conventional engine, supplied via onboard gas tanks, in volumes that displace between 30-70% of the energy from diesel.

Conversion 259

Conversion Hydrogen Fuel Vehicles 259

Green Car Congress

MARCH 9, 2020

Researchers from the Dalian Institute of Chemical Physics and the University of Chinese Academy of Sciences have developed a photocatalyst for the selective decarboxylation of fatty acids to produce diesel- and jet-range molecules under mild conditions (30?°C, C, H 2 pressure ?0.2?MPa). Industrial low-value fatty acid mixtures—e.g.,

Diesel 291

Diesel Conversion Range Hydrogen 291

Green Car Congress

NOVEMBER 14, 2014

Audi’s latest e-fuels project is participation in a a pilot plant project in Dresden that produces diesel fuel from water, CO 2 and green electricity. Nearly 80% of that can be converted into synthetic diesel. diesel—is free of sulfur and aromatics, and features a high cetane number. This fuel—Audi e?diesel—is

Audi 400

Audi Water Diesel Fuel 400

Green Car Congress

AUGUST 30, 2019

Since 2018, Volkswagen has used only SCR exhaust gas treatment systems with its diesel engines. This expands the window for aftertreatment of exhaust gases: even at exhaust gas temperatures close to the engine of +500°C, the system is still able to achieve very high conversion rates.

Diesel 308

Diesel Exhaust Convert Conversion 308

Green Car Congress

APRIL 8, 2022

Mercedes-Benz Trucks is introducing the third generation of its OM 471 heavy-duty diesel engine this year; the engine will deliver increased fuel efficiency and compliance with the strictest emissions standards such as Euro VIe. In this way, the compression ratio of the six-cylinder in-line engine has been increased from 18.3:1

Mercedes 435

Mercedes Diesel Oil Exhaust 435

Green Car Congress

JULY 13, 2022

Traditional locomotives run on diesel fuel, emitting high levels of NO x , PM, and CO 2. OptiFuel is developing modular repower kits for diesel locomotives and new locomotives in all lengths, horsepower levels, and track gauges. For line-haul operations in the US, RNG is the only practical zero-emission diesel-alternative solution.

Diesel 418

Diesel Argentina Powered Power 418

Green Car Congress

AUGUST 27, 2018

ABS has confirmed the successful conversion of a slow-speed marine diesel engine to operate on ethane as a fuel. The 15-day long conversion followed engine performance and emissions testing at Kawasaki in Japan, to prove the principle that burning ethane in the Navigator ME-GI engines would be possible. Earlier post.).

Mariner 218

Mariner Conversion Engine Fuel 218

Green Car Congress

FEBRUARY 9, 2021

a Canada-based company specializing in the design of electric propulsion systems for heavy-duty vocational vehicles, has launched an all-electric system at the same purchase price as diesel alternatives. Développement Effenco Inc.,

All-Electric 435

All-Electric Diesel Price Canada 435

Green Car Congress

JUNE 23, 2014

So far, Ruth noted, the new engine has achieved target engine-out emissions (EOE), performance and fuel economy; aftertreatment catalyst performance has met or exceeded the targeted conversion rates, enabling an increased allowance on engine out HC. diesel weighs 362 lbs (164 kg), while the ECS weighs 152 lbs (69 kg). Earlier post.).

Fuel Economy 357

Fuel Economy Economy Gasoline Downsizing 357

Green Car Congress

JUNE 10, 2020

The company’s mission is to eliminate the need for fossil fuels by removing CO 2 from the air and turning it into gasoline, jet fuel and diesel that can immediately be used in standard vehicles with no modifications. The effective upgrading of alcohols to gasoline, diesel, and jet fuels. to C 2 fuel products such as ethanol.

Gasoline 321

Gasoline Carbon Conversion BMW 321

Green Car Congress

AUGUST 14, 2023

The experimental results showed that DME operation retains the performance on the base diesel engine (338 kW peak power) while significantly reducing the engine-out emissions. Transient operation is unproblematic and very low emissions can be achieved using the same exhaust gas treatment system as for diesel. Soltic et al.

Engine 368

Engine Emissions Diesel Fuel 368

Green Car Congress

MAY 27, 2021

By using hydrogen to displace diesel directly in the engine, ULEMCo’s dual fuel technology H2ICED enables vehicle owners to reduce their carbon emissions by up to 40%, as well as offering a practical solution that is immediately available. The existing diesel fleet replacement cycle in Australia is generally between 7-20 years.

Australia 259

Australia Conversion Hydrogen Market 259

Green Car Congress

MARCH 8, 2019

Prof Huang of the Guangzhou Institute of Energy Conversion analyzed the MnO 2 catalyst material after exposure to simulated exhaust gas containing both SO 2 and NO 2 and found that both manganese nitrate and manganese sulfate were produced. MnO 2 reacts with sulfur and nitrogen oxides to produce sulfates and nitrates, respectively.

Exhaust 320

Exhaust Ozone Japan Diesel 320

Green Car Congress

JULY 22, 2021

US production capacity for renewable diesel could increase significantly through 2024, based on announced projects and those that are under construction, according to the US Energy Information Administration (EIA). As of the end of 2020, we estimate US production capacity for renewable diesel totaled nearly 0.6

Renewable 259

Renewable Diesel California Convert 259

Green Car Congress

FEBRUARY 23, 2021

In exchange for long-term, discounted fuel contracts with fleets, Hydra installs hydrogen-diesel co-combustion conversion kits into existing semi-trucks and provides the fueling infrastructure for green hydrogen sourced from chemical producers such as Chemtrade.

Hydrogen 301

Hydrogen Fleet Commercial Green 301

Green Car Congress

MAY 18, 2019

The ethers can be used as cetane-improvers in diesel fuel, while the olefins can be hydrogenated and blended with gasoline or oligomerized and hydrogenated to jet-range paraffins. The numbers depicted are carbon flows based on a process in which Guerbet coupling is performed at 50% conversion and etherification is performed at 65% conversion.

Convert 249

Convert Diesel Range Conversion 249

Green Car Reports

MAY 13, 2022

In addition to building new zero-emission trucks, what if older diesel trucks were converted to hydrogen fuel-cell power? Daimler Truck North America and diesel-engine manufacturer Cummins will update older Daimler-built Freightliner Cascadia semi trucks with Cummins-supplied fuel-cell.

Diesel 206

Diesel Conversion North America Fuel 206

Green Car Congress

FEBRUARY 22, 2023

Developed in conjunction with partners—Parker Hannifin and converted by Volvo Group’s own CE Engineering Solutions—the 20-ton L120H Electric Conversion will be commercially available for selected customers in Europe during 2023. The L120H Electric Conversion will be available this year for selected customers in Europe.

Conversion 225

Conversion Volvo Electrical Electric 225

Green Car Congress

APRIL 23, 2020

developer of Dynamic Skip Fire cylinder deactivation technology ( earlier post ), collaborated on a significant technical demonstration of diesel Dynamic Skip Fire (dDSF) cylinder deactivation. Cummins’ X15 Efficiency Series 6-cylinder diesel engine enhanced with Tula’s diesel Dynamic Skip Fire (dDSF). Cummins Inc.

Diesel 286

Diesel Emissions Exhaust Engine 286

Green Car Congress

FEBRUARY 5, 2023

Portantino (D-25) and Josh Newman (D-29) introduced Senate Bill 301 , a bill sponsored by the Specialty Equipment Market Association (SEMA), to create a financial rebate program for converting gas and diesel-powered motor vehicles into zero-emissions-vehicles (ZEVs). ZEV conversions are a rapidly growing market, SEMA said.

Conversion 210

Conversion California Convert Affordable 210

Green Car Congress

MAY 6, 2022

CAT-DEF—Catalyzed Diesel Exhaust Fluid—is an SwRI-developed catalyst- and surfactant-modified diesel exhaust fluid (DEF) solution. The internally funded advancement successfully reduced heavy-duty diesel engine nitrogen oxide (NO x ) emissions to meet the California Air Resources Board (CARB) 2027 standards.

Diesel 284

Diesel Emissions Exhaust Engine 284

Green Car Congress

AUGUST 3, 2020

Anelise Lara, the head of Petrobras’ refining, announced that the company is ready to begin production of renewable diesel from soy or other edible oils at commercial scale. Petrobras recently successfully concluded tests on an industrial scale for the production of renewable diesel.

Renewable 236

Renewable Diesel Production Oil 236

Green Car Congress

NOVEMBER 24, 2018

In Italy, Eni and Hera signed a partnership agreement with the aim of converting used vegetable oil into renewable diesel for Hera’s waste collection vehicles. Green Diesel—renewable diesel—is produced by Ecofining technology developed in Eni’s laboratories in collaboration with Honeywell UOP.

Waste 207

Waste Oil Renewable Diesel 207

Green Car Congress

SEPTEMBER 23, 2020

Tula Technology is presenting its diesel Dynamic Skip Fire (dDSF) technology ( earlier post ) at the 4 th Future Diesel Powertrain Summit China 2020 on 24-25 September 2020 in Shanghai, China. This allows for more efficient conversion of pollutants in the catalyst and reduced NO x , at no additional after treatment hardware cost.

Diesel 221

Diesel Future Fuel Economy 2020 221

Green Car Congress

MARCH 25, 2022

In its Annual Energy Outlook 2022 (AEO2022) Reference case, which reflects current laws and regulations, the US Energy Information Administration (EIA) projects that renewable diesel supply (domestic production and net imports) will exceed biodiesel supply in the near term.

Diesel 221

Diesel Renewable Supplies Parts 221

Green Car Congress

SEPTEMBER 24, 2018

Abellio Rail Mitteldeutschland, Alstom, Nahverkehrsservice Sachsen-Anhalt GmbH (NASA) and Rolls-Royce plan to implement jointly a new hybrid drive solution on Abellio’s fleet of Coradia Lint diesel trains. Subsequent conversion of the entire fleet of 54 Coradia Lint vehicles is under consideration.

Diesel 236

Diesel Hybrid Luxembourg Conversion 236

Green Car Congress

AUGUST 13, 2020

Researchers used reductive etherification chemistry to convert alcohol and ketone substrates derived from microbial carboxylic acids into an ether bioblendstock for use when blended into conventional diesel fuel. Production of renewable diesel bioblendstocks through reductive etherification of alcohols and ketones. Hafenstine et al.

Waste 221

Waste Renewable Diesel Cleaner 221

Green Car Congress

JULY 28, 2023

In June, CPKC and CSX Corporation announced their intent to enter into a joint venture for the building and deployment of hydrogen locomotive conversion kits for diesel electric locomotives. As an initial step in the collaboration, CSX plans to convert one of its diesel locomotives using a hydrogen conversion kit developed by CPKC.

Hydrogen 370

Hydrogen Kansas City Fuel West Virginia 370

Green Car Congress

AUGUST 5, 2021

A new report from the US Department of Energy (DOE) Co-Optima initiative identifies the top 13 diesel fuel blendstocks from biomass resources that could reduce harmful emissions from medium- to heavy-duty diesel vehicles. Hydroprocessed esters and fatty acids (also called renewable diesel). Fatty acid fusel esters. Gaspar, D.

Diesel 259

Diesel Fuel Emissions Waste 259

Green Car Congress

APRIL 14, 2023

Partnering with UK electric vehicle (EV) conversion experts, Electrogenic , Babcock will convert four in-service military Land Rovers, two protected vehicles and two general service, from diesel-fueled to EV using a drop-in kit and modified battery system.

Land Rover 195

Land Rover Conversion Electric Vehicles Vehicles 195

Green Car Congress

APRIL 27, 2021

Axens Vegan technology is designed to hydrotreat a wide range of lipids and to produce a flexible slate of low-density and high cetane renewable diesel as well as renewable jet fuel. Renewable diesel and jet production is a simple two-step process. Vegan technology is based on catalysts developed, manufactured and provided by Axens.

Renewable 243

Renewable Diesel California Fuel 243

Green Car Congress

JULY 10, 2023

MAN Energy Solutions has signed a Conversion Commitment Agreement with Seaspan Corporation (Seaspan), a global leader in containership ownership and management in collaboration with Hapag-Lloyd, one of the leading global liner shipping companies. This agreement includes 45 optional engine retrofit solutions. LGIM variants. Earlier post.)

Fuel 370

Fuel Conversion Mariner Engine 370