Green Car Congress

JUNE 23, 2014

The original project target was Tier 2 Bin 2 emissions, but in August 2013, it was agreed to shift that to the Tier 3 target—essentially the same with combined NO x and NMOG emissions, but more strict with CO and PM. Installed in a 2013 Fusion. Split, parallel, cross-flow cooling with integrated exhaust manifold.

Fuel Economy 247

Fuel Economy Economy Ford Engine 247

Green Car Congress

SEPTEMBER 9, 2014

The ADEPT project was launched in 2013 to demonstrate the potential for 48V-based intelligent electrification to deliver full hybrid-scale fuel efficiency from a highly cost-effective package. An effective limitation on downsizing, however, is the delivery of acceptable driveability characteristics and launch performance.

Diesel 231

Diesel Downsizing Lead Acid Gasoline-Electric 231

Green Car Congress

JUNE 29, 2016

The concept of “intelligent electrification” enables highly aggressive engine downsizing and down-speeding beyond what might normally be possible other than through more expensive hybridization approaches. Further energy recovery is achieved from CPT’s exhaust-mounted 48V turbine integrated exhaust gas energy recovery system known as TIGERS.

Emissions 150

Emissions Hybrid Affordable Future 150

Green Car Congress

MAY 27, 2014

In November 2013, Nissan introduced the new Skyline with Nissan’s novel one-motor two-clutch hybrid system in every grade. The new turbocharged gasoline engine achieves a superior level of engine performance with maximum power output of 155kW (211ps) while improving fuel economy with its downsized displacement. Earlier post.)

Japan 262

Japan Nissan Fuel Economy Economy 262

Green Car Congress

JUNE 29, 2012

For the 2013 XF and XJ lineup, Jaguar is adding two new downsized forced induction gasoline powerplants: 3.0-liter The turbine housing for the low inertia turbocharger is integrated with the lightweight, thin-walled exhaust manifold, shortening the engine and catalyst warm up times and reducing emissions.

Gasoline 225

Gasoline Engine 2013 MPH 225

Green Car Congress

MAY 8, 2013

At the recent 2013 SAE World Congress, engineers from Bosch and AVL presented papers on progress in the ACCESS project, describing the design, combustion development and controls development for a resulting 4-cylinder gasoline turbocharged direct injection (GTDI) engine with part-load HCCI capability. Engines 6(1)doi: 10.4271/2013-01-0287.

Fuel Economy 278

Fuel Economy Economy Fuel Engine 278

Green Car Congress

JANUARY 12, 2010

Ford expects up to 90% of its nameplates sold in North America will be available with downsized direct-injected turbocharged engines by 2013. As previously announced, BorgWarner will also supply turbochargers for rear-wheel drive trucks featuring Ford’s 3.5-liter liter V6 EcoBoost engine.

Ford 236

Ford Engine North America Fuel Economy 236

Green Car Congress

APRIL 17, 2014

Due to the lower exhaust enthalpy of lower temperature engines using PPCI, it is difficult to produce intake boost with acceptable boost system parasitis. A practical powertrain system with robust PPCI combustion is needed, including injection, valvetrain, boost, and exhaust subsystems. Valvetronic 2013. —Sellnau et al.

Gasoline 304

Gasoline Engine Fuel Wisconsin 304

Green Car Congress

APRIL 19, 2013

The team presented a paper on their work at the 2013 SAE World Congress in Detroit. Given the properties of the fuel blend, improved fuel efficiencies can be generated by several approaches, including downsizing/downspeeding; increased compression ratio; reduced enrichment; and the leveraging of improved efficiency at part load.

Engine 253

Engine Fuel Ford Future 253

Green Car Congress

MARCH 20, 2013

Compared to gasoline, the lower alcohols exhibit high latent heat of vaporisation and anti-knock rating, which makes them attractive for use in future “downsized” highly boosted SI engines that endure significantly higher peak in-cylinder pressures and temperatures. The system is based on a shaft-in-shaft cam operating principle.

Gasoline 225

Gasoline Exhaust Downsizing Engine 225

Green Car Congress

OCTOBER 16, 2012

The roll-out of the new engine family—developed in Ruesselsheim, Germany—will begin in early 2013. Achieving these goals enabled vehicle integration that can tune primary engine orders in the induction and exhaust systems to meet specific vehicle objectives. Turbocharging.

Gasoline 350

Gasoline Engine Fuel Power 350

Green Car Congress

JANUARY 28, 2014

liter, normally-aspirated V8 engine used from 2006 to 2013 is replaced by a turbo 1.6-liter A sole single-stage compressor and single-stage exhaust turbine are used for pressure charging. Per the regulations, the Mercedes team downsized their internal combustion engine (ICE) to a 1.6 The F1 W05. Click to enlarge. Turbocharger.

2014 252

2014 Mercedes Fuel Power 252

Green Car Congress

APRIL 21, 2014

That confirmed TOYOTA Racing’s sixth win from 15 WEC races, its second consecutive victory following its triumph in the 2013 season finale in Bahrain. TOYOTA cars have raced in 15 Le Mans 24 Hours races, achieving a best result of second place on four occasions (1992, 1994, 1999 & 2013). 919 Hybrid pit stop. Click to enlarge.

Porsche 220

Porsche Hybrid Toyota Bahrain 220

Green Car Congress

NOVEMBER 21, 2011

The EcoBoost approach enables the downsizing engine capacity—replacing naturally-aspirated engines with much smaller units without sacrificing power output. By 2013, the company plans globally to produce 1.5 By 2013, the company plans globally to produce 1.5 million EcoBoost engines annually. EcoBoost in China.

Fuel Economy 236

Fuel Economy China Economy 2015 236

Green Car Congress

FEBRUARY 10, 2014

Many approaches have been attempted to achieve CAI operation on the four-stroke spark ignition engines, such as intake air heating, high compression ratio, dual fuel, recycling the exhaust gas, and so on. To minimize the air short-circuiting rate, the intake and exhaust valve timings were adjusted. Earlier post , earlier post.).

Gasoline 186

Gasoline Engine Exhaust Fuel 186

Green Car Congress

NOVEMBER 22, 2016

In 2013 the European Parliament recommended an “indicative range” of 68–78 g/km for 2025, while holding out the possibility that even lower targets should be considered if justified. Under current European Union regulations, average new car CO 2 emissions must decrease from the present 120 grams per kilometer (g/km) to 95 g/km by 2021.

CO2 150

CO2 2014 Cars Exhaust 150

Green Car Congress

AUGUST 25, 2015

Knock and fuel octane rating are becoming increasingly important due to many powertrain design trends including downsizing, downspeeding, cylinder deactivation, and hybridization. … The vast majority (87%) of gasoline sold in the US in 2013 was regular grade, with 10% premium and 3% midgrade. In their study, Leone et al.

Engine 150

Engine Fuel GM Ford 150

Green Car Congress

OCTOBER 8, 2015

Having better control over the combustion process reduces the emission load on the exhaust aftertreatment systems. Eminox SCRT technology can significantly reduce harmful diesel exhaust gases, particularly in urban operating conditions. The need for this technology is driven by ever tightening legislation.

Vehicles 150

Vehicles Exhaust Emissions Diesel 150

Green Car Congress

OCTOBER 16, 2013

Homogeneous GDI provides fuel efficiency benefits from charge air cooling, more facile turbocharging, and the downsizing that these permit. Schematic diagram of test vehicle engine & exhaust system and PM sampling systems. —Maricq et al. Credit: ACS, Maricq et al. Click to enlarge. Fuel injectors were side-mounted. Resources.

Standards 246

Standards Emissions Miles Engine 246

Green Car Congress

SEPTEMBER 6, 2012

Ford projects that two-thirds of all the company’s vehicles in Europe will be leaders, or among the very best, in terms of fuel efficiency by 2013. The Fiesta ST is expected to deliver best-in-class fuel efficiency when it goes on sale in 2013. meter unobstructed passenger opening, as well as SYNC and the 1.0-liter

Fuel Economy 261

Fuel Economy Europe Ford Economy 261

Green Car Congress

APRIL 24, 2012

Pinnacle has signed a licensing and joint development agreement with a major, as yet unnamed, Asian vehicle OEM, with lower power products targeted for two- and three-wheel applications in the developing country markets expected to be available in the first quarter of 2013. Pinnacle Engines’ 4-stroke opposed-piston engine. Click to enlarge.

Light 304

Light Fuel Economy Engine Fuel 304

Green Car Congress

NOVEMBER 30, 2011

Further, implementation of VTC and high-capacity EGR (Exhaust Gas Recirculation) to both the intake and exhaust ports realizes significantly reduced friction. By downsizing from the present 2.2L This employs direct injection technology and the Atkinson cycle using the DOHC, VTEC technologies as the base. Diesel engine.

Honda 246

Honda Plug-in Hybrid Engine 246

Green Car Congress

OCTOBER 8, 2013

In a paper presented at the SAE 2013 World Congress, Kalghatgi and his colleagues argued that: Demand for transport energy is growing, but this growth is skewed heavily toward commercial transport, such as heavy road, aviation, marine and rail which uses heavier fuels like diesel and kerosene. Engines 6(1):101-119, doi: 10.4271/2013-01-0267.

Gasoline 207

Gasoline Fuel Range Diesel 207

Green Car Congress

FEBRUARY 24, 2009

A 2010 version of the MCE-5 VCRi engine will be equipped with GDI, optimized combustion chambers as well as the advanced management of engine temperature, of the cylinder head, pistons and exhaust manifold. This constitutes a strong response to the durability problem of highly downsized high-loaded engines.

Engine 231

Engine Vehicles Gasoline-Electric MPG 231

Green Car Congress

SEPTEMBER 16, 2009

Variable valve timing on both intake and exhaust camshafts helps 4-cylinder Ford EcoBoost engines optimize gas flow through the combustion chamber at all engine speeds, improving efficiency and performance, particularly at part load. By 2013, Ford expects to offer EcoBoost engines in 90% of its global product lineup.

Engine 186

Engine Ford Downsizing United Kingdom 186

Green Car Congress

FEBRUARY 1, 2012

Volkswagen has already announced the launch of the latter within the MQB in 2013 in the new Golf Blue-e-Motion. In the familiar gasoline engines of the previous EA111 series, the (‘hot’) exhaust side was at the front, and the engines were mounted with a forward tilt. EA211 series gasoline engines. Modular layout of the EA211.

Engine 294

Engine Exhaust Diesel Gasoline-Electric 294

Green Car Congress

MAY 17, 2013

Dedicated ethanol (or E85) engines have the promise to improve efficiency substantially over comparable regular gasoline engines through direct-injection, increased geometric CR, variable valve timing, exhaust gas recirculation, aggressive turbocharging, and downsizing and/or downspeeding. Xiaoyu Yan, Oliver R. Inderwildi, David A.

Fuel 210

Fuel Energy Gasoline-Electric Gasoline 210

Green Car Congress

AUGUST 4, 2011

Since this energy loss is primarily thermal in nature and can be attributed to the exhaust, cooling system, and engine and transmission surfaces, Mazda’s R&D team’s central focus is on improving the engine’s thermal efficiency cost-effectively. Extreme compression ratio rather than downsizing. Although downsizing—i.e.,

Mazda 322

Mazda Engine Gasoline Diesel 322

Green Car Congress

DECEMBER 20, 2009

As part of an aggressive deployment strategy for improving fuel efficiency across its product line-up in the near-to medium-term, Ford will offer its first-generation turbocharged, gasoline direct-injection EcoBoost engines ( earlier post ) in 90% of its product lineup by 2013. Planning background. ” First-generation EcoBoost.

Fuel Economy 186

Fuel Economy Economy Ford Downsizing 186